VW Passat
The maintenance instruction
1. Maintenance service
2. Engines
3. Cooling system
4. Fuel system
5. Engine management
6. An exhaust system
7. Transmission
8. A running gear
9. A steering
10. Brake system
11. A body
12. Heating, ventilation
- 13. An electric equipment
13.2. The general information
13.3. Electric chains
13.4. Safety locks
13.5. Rules of care of the accumulator
13.6. Accumulator check
13.7. Accumulator gymnastics
13.8. The accumulator
13.9. Gymnastics system
13.10. The generator
13.11. Replacement of brushes of the generator and a pressure regulator
13.12. System of start of the engine
13.13. A starter
13.14. The traction relay of a starter
13.15. Replacement of bulbs of external illumination
13.16. Replacement of bulbs of internal illumination
13.17. Devices of external illumination
13.18. The executive engine of the proof-reader of light of headlights
13.19. Adjustment of light of headlights
13.20. Gas-discharge lamps of headlights of a passing light
13.21. A combination of devices
13.22. Multipurpose switches of a steering column
13.23. Switches
13.24. A radio receiver
13.25. High-frequency loudspeakers
13.26. Low-frequency loudspeakers
13.27. The aerial
13.28. Check of a heater of back glass
13.29. The engine of a screen wiper of a windscreen
13.30. The engine of a screen wiper of back glass
13.31. The pump стеклоомывателя
13.32. System of the central blocking of locks
13.33. The basic malfunctions of the generator
13.34. The basic malfunctions of a starter
13.35. Electric schemes
|
Arrangement of electric sockets on a back part of a combination of devices
1 – a 34-contact electric socket of green colour,
2 – a 20-contact electric socket of red colour (it is established only on 3rd variant of execution),
3 – a control lamp of a headlight of 1,12 Vt, |
4 – a control lamp of exhaust gases of 1,12 Vt,
5 – a control lamp of work of turns of the trailer of 1,12 Vt,
6 – a 32-contact electric socket of dark blue colour |
Arrangement of screws of fastening of a combination of devices
Cнятие
Removal of the bottom lateral furnish from outside the driver
|
|
1 – заглушка,
2 – the screw,
3 – the screw,
4 – lateral furnish |
Removal of the bottom panel of furnish of the panel of devices from outside the driver
|
|
1 – a lateral cover,
2 – the bottom panel of furnish,
3 – the switch of light,
4 – the proof-reader of light of headlights
Arrows note an arrangement of screws of fastening of the bottom panel of furnish. |
Removal of decorative facing under a combination of devices
|
|
1 – an inside of facing,
2 – a clip,
3 – decorative facing |
The prevention In a combination of devices it is possible to make only replacement of control bulbs накаливания. At failure of one of indexes or in the presence of any other defect it is necessary to replace a combination of devices in gathering.
| PERFORMANCE ORDER |
| 1. Remove switches of a steering column. |
| 2. Remove the bottom lateral furnish from outside the driver for what remove заглушки, closing screws of fastening, and unscrew screws, fig. Removal of the bottom lateral furnish from outside the driver see. Move forward and remove the bottom lateral furnish from outside the driver. |
| 3. Remove the bottom furnish of the panel of devices from outside the driver. Remove a lateral decorative overlay from the left end face of the panel of devices. |
| 4. Unscrew screws (arrows), крепящие the bottom panel of furnish of the panel of devices from outside the driver, fig. Removal of the bottom panel of furnish of the panel of devices from outside the driver see. |
| 5. Disconnect electric sockets from the switch of light of headlights and the proof-reader of light of headlights. |
| 6. Raise from the inside decorative facing (1) and, using a rigid clip (2), fix it in this position, fig. Removal of decorative facing under a combination of devices see. |
| 7. Unscrew 4 screws and remove decorative facing, fig. Removal of decorative facing under a combination of devices see. |
| 8. In the bottom part of a combination of devices unscrew two screws and remove a combination of devices, fig. the Arrangement of screws of fastening of a combination of devices see. |
| 9. Disconnect from a back part of a combination of devices electric sockets, the Arrangement of electric sockets fig. see a back part of a combination of devices. |
| 10. If necessary replace lamps накаливания. |
|
Installation
| PERFORMANCE ORDER |
| 1. Installation is made in sequence, return to removal. |
| 2. If the new combination of devices is established modify indications of the Service-indicator and the counter of kilometres. |
|
|
|
